褚廷湘, 苏媛媛, 陈月霞,.水分散失对破碎煤体空隙率变化的影响研究[J].河南理工大学学报（自然科学版）,2023,42(3):42-49.

CHU T X, SU Y Y, CHEN Y X.Study on the influence of water losing on crushed coal porosity[J].Journal of Henan Polytechnic University(Natural Science) ,2023,42(3):42-49.

水分散失对破碎煤体空隙率变化的影响研究

褚廷湘1, 苏媛媛1, 陈月霞2

1.华北科技学院 矿山安全学院，河北 三河  065201;2.华北科技学院 应急技术与管理学院，河北 三河  065201

摘要:为了研究破碎煤体水分散失规律与空隙率演变特征，通过控制水浸煤样粒径、环境温度和初始含水量，开展破碎煤体水分散失与空隙率变化实验测试与分析。结果表明：经过水浸泡后所有煤样宏观体积较干燥状态下的均有所增加，随着水分散失，其空隙率呈现下降趋势，但仍大于干燥状态下的；环境温度越高、粒径越小、初始含水量越大的煤样，水浸后空隙率越大，水分散失阶段具有相同规律；水浸的溶胀效应、受热膨胀效应、颗粒间液桥拉力降低等因素是造成煤体水分散失过程中空隙率变化的主要原因；失水后煤样残留部分的不等量空隙体积导致空隙率增大，煤氧接触面积增大。

关键词:水浸煤;水分散失规律;空隙率;溶胀

doi:10.16186/j.cnki.1673-9787.2022010037

基金项目:国家自然科学基金资助项目（52274199）

收稿日期:2022/01/13

修回日期:2022/08/31

出版日期:2023/05/25

Study on the influence of water losing on crushed coal porosity

CHU Tingxiang1, SU Yuanyuan1, CHEN Yuexia2

1.School of Mine Safety，North China Institute of Science and Technology，Sanhe  065201，Hebei，China;2.School of Emergency Technology and Management，North China Institute of Science and Technology，Sanhe  065201，Hebei，China

Abstract:In order to study the water loss law and porosity evolution characteristics of broken coal，the experimental test and analysis on the relationship between water loss and porosity change of broken coal were carried out by controlling the environmental temperature，coal sample particle size and initial water content.The results showed that after soaking，the macroscopic volume of all coal samples increased compared with that of dry coal samples，and the porosity decreased with the dispersion of water，which was still larger than that of dry coal samples；The higher the ambient temperature was，the smaller the particle size was and the greater the initial water content was，the greater the porosity was after water immersion，and the same law still existed in the stage of water loss；The swelling effect of water immersion，the effect of thermal expansion and the decrease of liquid bridge tension between particles were the main causes of the change of void ratio in the process of coal moisture loss；For the coal sample after water loss，the residual part had unequal void volume，resulting in the increase of void ratio and coal oxygen contact area.

Key words:water soaked coal;water loss law;porosity;swelling

水分散失对破碎煤体空隙率变化的影响研究_褚廷湘.pdf